Edgar Filing: PGT, Inc.

form10q2_2009.htm

UNITED STATES SECURITIES AND EXCHANGE COMMISSION

Washington, D.C. 20549

FORM 10-Q

R	QUARTERLY REPORT PURSUANT TO SECTION 13 OR 15(d) OF THE SECURITIES EXCHANGE ACT OF 1934
	For the quarterly period ended July 4, 2009
OR
£	TRANSITION REPORT PURSUANT TO SECTION 13 OR 15(d) OF THE SECURITIES EXCHANGE ACT OF 1934
	For the transition period from to

Commission file number 000-52059

PGT, Inc.

1070 Technology Drive

North Venice, FL 34275

Registrant’s telephone number: 941-480-1600

State of Incorporation		IRS Employer Identification No.
Delaware		20-0634715

Indicate by check mark whether the registrant (1) has filed all reports required to be filed by Section 13 or 15(d) of the Securities Exchange Act of 1934 during the preceding 12 months (or for such shorter period that the registrant was required to file such reports), and (2) has been subject to such filing requirements for the past 90 days.

Yes R No £

Indicate by check mark whether the registrant has submitted electronically and posted on its corporate Web site, if any, every Interactive Data File required to be submitted and posted pursuant to Rule 405 of Regulation S-T (§232.405 of this chapter) during the preceding 12months (or for such shorter period that the registrant was required to submit and post such files).

Yes £ No £*

Indicate by check mark whether the registrant is a large accelerated filer, an accelerated filer or a non-accelerated filer. See definition of accelerated filer and large accelerated filer in Rule 12b-2 of the Exchange Act.

Large accelerated filer o	Accelerated filer þ	Non-accelerated filer o	Smaller reporting companyo
		(Do not check if a smaller reporting company)

Indicate by check mark whether the registrant is a shell company (as defined in Rule 12b-2 of the Exchange Act).

Yes £ No R

Indicate the number of shares outstanding of each of the issuer’s classes of common stock, as of the latest practicable date.

Common Stock, $0.01 par value – 35,685,245 shares, as of July 31, 2009.

* Registrant is not subject to the requirements of Rule 405 of Regulation S-T at this time.

Table of Contents

PGT, INC.

TABLE OF CONTENTS

	Page
	Number
Part I. Financial Information
Item 1. Condensed Consolidated Financial Statements (unaudited)
Condensed Consolidated Statements of Operations	3
Condensed Consolidated Balance Sheets	4
Condensed Consolidated Statements of Cash Flows	5
Notes to Condensed Consolidated Financial Statements	6
Item 2. Management’s Discussion and Analysis of Financial Condition and Results of Operations	19
Item 3. Quantitative and Qualitative Disclosures About Market Risk	28
Item 4. Controls and Procedures	28
Part II. Other Information
Item 1. Legal Proceedings	29
Item 1A. Risk Factors	29
Item 2. Unregistered Sales of Equity Securities and Use Of Proceeds	29
Item 3. Defaults Upon Senior Securities	29
Item 4. Submission of Matters to a Vote of Security Holders	30
Item 5. Other Information	30
Item 6. Exhibits	30

- 2 -

Table of Contents

PART I — FINANCIAL INFORMATION

ITEM 1. CONDENSED CONSOLIDATED FINANCIAL STATEMENTS

PGT, INC.

CONDENSED CONSOLIDATED STATEMENTS OF OPERATIONS

(in thousands, except per share amounts)


	Three Months Ended					Six Months Ended
	July 4,		June 28,			July 4,			June 28,
	2009		2008			2009			2008
	(unaudited)					(unaudited)
Net sales	$	46,867	$	60,100		$	88,381		$	114,936
Cost of sales		32,247		38,609			63,866			77,374

Gross margin		14,620		21,491			24,515			37,562

Goodwill impairment charge		-		92,000			-			92,000
Selling, general and administrative expenses		12,541		16,165			27,552			32,434

Income (loss) from operations		2,079		(86,674	)		(3,037	)		(86,872	)

Interest expense, net		1,737		2,190			3,315			4,917
Other expense (income), net		-		51			6			(56	)

Income (loss) before income taxes		342		(88,915	)		(6,358	)		(91,733	)

Income tax benefit		-		(12,266	)		-			(13,297	)

Net income (loss)	$	342	$	(76,649	)	$	(6,358	)	$	(78,436	)

Net income (loss) per common share:
Basic	$	0.01	$	(2.65	)	$	(0.18	)	$	(2.72	)

Diluted	$	0.01	$	(2.65	)	$	(0.18	)	$	(2.72	)

Weighted average shares outstanding:
Basic		35,240		28,934			35,220			28,832

Diluted		35,622		28,934			35,220			28,832

The accompanying notes are an integral part of these condensed consolidated financial statements.

- 3 -

Table of Contents

PGT, INC.

CONDENSED CONSOLIDATED BALANCE SHEETS

(in thousands except per share amounts)


	July 4,			January 3,
	2009			2009
	(unaudited)
ASSETS
Current assets:
Cash and cash equivalents	$	14,609		$	19,628
Accounts receivable, net		18,001			17,321
Inventories		9,199			9,441
Deferred income taxes		529			1,158
Other current assets		4,325			5,569

Total current assets		46,663			53,117

Property, plant and equipment, net		69,540			73,505
Other intangible assets, net		69,893			72,678
Other assets, net		1,119			1,317

Total assets	$	187,215		$	200,617

LIABILITIES AND SHAREHOLDERS' EQUITY
Current liabilities:
Accounts payable and accrued liabilities	$	14,055		$	14,582
Current portion of long-term debt		102			330

Total current liabilities		14,157			14,912

Long-term debt		82,216			90,036
Deferred income taxes		17,844			18,473
Other liabilities		2,901			3,011

Total liabilities		117,118			126,432

Commitments and contingencies (note 10)

Shareholders' equity:
Preferred stock; par value $.01 per share; 10,000 shares authorized; none outstanding		-			-
Common stock; par value $.01 per share; 200,000 shares authorized; 35,685 and
35,392 shares issued and 35,300 and 35,197 shares outstanding at
July 4, 2009 and January 3, 2009, respectively		353			352
Additional paid-in-capital		241,555			241,177
Less: Treasury shares at cost		(6	)		-
Accumulated other comprehensive loss		(2,069	)		(3,966	)
Accumulated deficit		(169,736	)		(163,378	)

Total shareholders' equity		70,097			74,185

Total liabilities and shareholders' equity	$	187,215		$	200,617

The accompanying notes are an integral part of these condensed consolidated financial statements.

- 4 -

Table of Contents

PGT, INC.

CONDENSED CONSOLIDATED STATEMENTS OF CASH FLOWS

(in thousands)


	Six Months Ended
	July 4,			June 28,
	2009			2008
	(unaudited)

Cash flows from operating activities:
Net loss	$	(6,358	)	$	(78,436	)
Adjustments to reconcile net loss to net cash
used in operating activities:
Depreciation		5,247			5,666
Amortization		2,785			2,785
Stock-based compensation		385			361
Excess tax benefits from stock-based compensation plans		-			(458	)
Deferred taxes		-			(13,395	)
Amortization of deferred financing costs		272			236
Derivative financial instruments		6			(56	)
Impairment charge		-			92,000
Loss on disposal of assets		90			6
Change in operating assets and liabilities:
Accounts receivable		(16	)		(2,257	)
Inventories		70			(1,103	)
Prepaid expenses and other current assets		861			2,098
Accounts payable, accrued and other liabilities		(1,127	)		1,601

Net cash provided by operating activities		2,215			9,048

Cash flows from investing activities:
Purchases of property, plant and equipment		(1,403	)		(1,957	)
Proceeds from sales of equipment		32			58
Net change in margin account for derivative financial instruments		2,197			-

Net cash provided by (used in) investing activities		826			(1,899	)

Cash flows from financing activities:
Payments of long-term debt		(8,000	)		(10,000	)
Payments of capital leases		(48	)		-
Purchases of treasury stock		(6	)		-
Adjustment to proceeds from issuance of common stock		(6	)		-
Proceeds from exercise of stock options		-			210
Excess tax benefits from stock-based compensation plans		-			458

Net cash used in financing activities		(8,060	)		(9,332	)

Net decrease in cash and cash equivalents		(5,019	)		(2,183	)
Cash and cash equivalents at beginning of period		19,628			19,479
Cash and cash equivalents at end of period	$	14,609		$	17,296

The accompanying notes are an integral part of these condensed consolidated financial statements.

- 5 -

Table of Contents

PGT, INC.

NOTES TO CONDENSED CONSOLIDATED FINANCIAL STATEMENTS

(unaudited)

NOTE 1. BASIS OF PRESENTATION

The accompanying unaudited condensed consolidated financial statements include the accounts of PGT, Inc. and its wholly-owned subsidiary (collectively the “Company”) after elimination of intercompany accounts and transactions. These statements have been prepared in accordance with the instructions to Form 10-Q and do not include all of the information and footnotes required by United States Generally Accepted Accounting Principles (“GAAP”) for complete financial statements. In the opinion of management, all adjustments (consisting only of normal recurring accruals) considered necessary for a fair presentation have been included. All significant intercompany accounts and transactions have been eliminated in consolidation. Operating results for the interim period are not necessarily indicative of the results that may be expected for the remainder of the current year or for any future periods. Each of our Company’s fiscal quarters ended July 4, 2009 and June 28, 2008 consisted of 13 weeks.

The condensed consolidated balance sheet as of January 3, 2009 is derived from the audited consolidated financial statements but does not include all disclosures required by GAAP. This condensed consolidated balance sheet as of January 3, 2009 and the unaudited condensed consolidated financial statements included herein should be read in conjunction with the more detailed audited consolidated financial statements for the year ended January 3, 2009 included in the Company’s most recent annual report on Form 10-K. Accounting policies used in the preparation of these unaudited condensed consolidated financial statements are consistent with the accounting policies described in the Notes to Consolidated Financial Statements included in the Company’s Form 10-K.

We have evaluated the condensed consolidated financial statements for subsequent events through the date of the filing of this Form 10-Q.

NOTE 2. RESTRUCTURINGS

On January 13, 2009 and March 11, 2009, we announced further restructurings of the Company as a result of continued analysis of our target markets, internal structure, projected run-rate, and efficiency. The restructurings resulted in a decrease in our workforce of approximately 250 employees and included employees at both our Venice, Florida and Salisbury, North Carolina locations. As a result of the restructurings, we recorded restructuring charges totaling $3.0 million in the first quarter of 2009, of which $1.4 million is classified within cost of sales and $1.6 million is classified within selling, general and administrative expenses in the accompanying condensed consolidated statement of operations for the six months ended July 4, 2009. The charges related primarily to employee separation costs.

The total costs incurred for the restructurings in 2008 and 2007 were $2.1 million and $2.4 million, respectively.

The following table provides information with respect to our accrual for restructuring costs:

- 6 -

Table of Contents

Accrued Restructuring Costs	Beginning of Period		Charged to Expense		Disbursed in Cash			End of Period
(in thousands)

Three months ended July 4, 2009:
2008 Restructuring	$	-	$	-	$	-		$	-
2009 Restructurings		403		-		(322	)		81
For the three months ended July 4, 2009	$	403	$	-	$	(322	)	$	81

Three months ended June 28, 2008:
2007 Restructuring	$	217	$	-	$	(217	)	$	-
2008 Restructuring		-		-		-			-
For the three months ended June 28, 2008	$	217	$	-	$	(217	)	$	-

Six months ended July 4, 2009:
2008 Restructuring	$	332	$	-	$	(332	)	$	-
2009 Restructurings		-		3,002		(2,921	)		81
For the six months ended July 4, 2009	$	332	$	3,002	$	(3,253	)	$	81

Six months ended June 28, 2008:
2007 Restructuring	$	850	$	-	$	(850	)	$	-
2008 Restructuring		-		1,752		(1,752	)		-
For the six months ended June 28, 2008	$	850	$	1,752	$	(2,602	)	$	-

NOTE 3. WARRANTY

We have warranty obligations with respect to most of our manufactured products. Warranty periods, which vary by product component, generally range from 1 to 10 years. However, the majority of the products sold have warranties on components which range from 1 to 3 years. The reserve for warranties is based on management’s assessment of the cost per service call and the number of service calls expected to be incurred to satisfy warranty obligations on recorded net sales. The reserve is determined after assessing our warranty history and estimating our future warranty obligations.

The following table provides information with respect to our warranty accrual:


	Beginning		Charged to								End of
Accrued Warranty	of Period		Expense		Adjustments			Settlements			Period
(in thousands)
Three months ended July 4, 2009	$	4,214	$	584	$	(75	)	$	(637	)	$	4,086

Three months ended June 28, 2008	$	4,835	$	902	$	(279	)	$	(748	)	$	4,710

Six months ended July 4, 2009	$	4,224	$	1,414	$	(125	)	$	(1,427	)	$	4,086

Six months ended June 28, 2008	$	4,986	$	1,999	$	(451	)	$	(1,824	)	$	4,710

- 7 -

Table of Contents

NOTE 4. INVENTORIES

Inventories consist principally of raw materials purchased for the manufacture of our products. We have limited finished goods inventory since all products are custom, made-to-order products and usually ship upon completion. Finished goods inventory costs include direct materials, direct labor, and overhead. All inventories are stated at the lower of cost (first-in, first-out method) or market value. Inventories consisted of the following at:


	July 4,		January 3,
	2009		2009
	(in thousands)

Finished goods	$	1,018	$	905
Work in progress		188		342
Raw materials		7,993		8,194

	$	9,199	$	9,441

NOTE 5. STOCK COMPENSATION EXPENSE

We account for stock-based compensation in accordance with Statement of Financial Accounting Standards (“SFAS”) No. 123(R), “Share-Based Payment” (SFAS 123(R)). This statement is a fair-value based approach for measuring stock-based compensation and requires us to recognize the cost of employee and non-employee directors’ services received in exchange for our Company’s equity instruments. Under SFAS 123(R), we are required to record compensation expense over an award’s vesting period based on the award’s fair value at the date of grant. We recorded compensation expense for stock based awards of $0.2 million for the second quarter of 2009 and $0.3 million for the second quarter of 2008. We recorded compensation expense for stock based awards of $0.4 million for the first half of 2009 and $0.4 million for the first half of 2008. As of July 4, 2009, there was $0.3 million and $0.4 million of total unrecognized compensation cost related to non-vested stock option agreements and non-vested restricted share awards, respectively. These costs are expected to be recognized in earnings on a straight-line basis over the weighted average remaining vesting period of 1.7 years.

NOTE 6. NET LOSS PER COMMON SHARE

Net loss per common share (“EPS”) is calculated in accordance with SFAS No. 128, “Earnings per Share”, which requires the presentation of basic and diluted EPS. Basic EPS is computed using the weighted average number of common shares outstanding during the period. Diluted EPS is computed using the weighted average number of common shares outstanding during the period, plus the dilutive effect of common stock equivalents.

Due to the net losses in the first half of 2009 and in the second quarter and first half of 2008, the effect of compensation plans is anti-dilutive. Basic and diluted weighted average common shares outstanding for the second quarter and first half of 2008 have been restated to give effect to the market value premium included in the rights offering that ended on September 4, 2008. There were shares of common stock of 1,409,181 for the second quarter and 1,856,662 for the first half of 2009 relating to stock option agreements excluded from the computation of diluted EPS in each period as they were anti-dilutive.

- 8 -

Table of Contents

The table below presents the calculation of EPS and a reconciliation of weighted average common shares used in the calculation of basic and diluted EPS for our Company:


	Three Months Ended					Six Months Ended
	July 4,		June 28,			July 4,			June 28,
	2009		2008			2009			2008
	(in thousands, except per share amounts)

Net income (loss)	$	342	$	(76,649	)	$	(6,358	)	$	(78,436	)

Weighted-average common shares - Basic		35,240		28,934			35,220			28,832
Add: Dilutive effect of stock compensation plans		382		332			191			388

Weighted-average common shares - Diluted		35,622		29,266			35,411			29,220

Net income (loss) per common share:
Basic	$	0.01	$	(2.65	)	$	(0.18	)	$	(2.72	)

Diluted	$	0.01	$	(2.65	)	$	(0.18	)	$	(2.72	)

NOTE 7. OTHER INTANGIBLE ASSETS

Other intangible assets are as follows:


							Original
	July 4,			January 3,			Useful Life
	2009			2009			(in years)
	(in thousands)
Other intangible assets:
Trademarks	$	44,400		$	44,400		indefinite

Customer relationships		55,700			55,700		10
Less: Accumulated amortization		(30,207	)		(27,422	)

Subtotal		25,493			28,278

Other intangible assets, net	$	69,893		$	72,678

Indefinite Lived Intangible Asset

The impairment evaluation for indefinite lived intangible assets, which for the Company are its trademarks, is conducted at the end of each fiscal year, or more frequently if events or changes in circumstances indicate that an asset might be impaired. The determination of fair value used in the impairment evaluation is based on discounted estimates of future projected cost savings attributable to ownership of the trademarks. The assumptions used in the estimate of fair value are generally consistent with past performance and are also consistent with the projections and assumptions used in current operating plans. Such assumptions are subject to change as a result of changing economic and competitive conditions. The determination of fair value is highly sensitive to changes in estimated future cash flows and changes in the discount rate used to evaluate the fair value of the trademarks. Estimated cash flows are sensitive to changes in the Florida housing market and changes in the economy, among other things.

- 9 -

Table of Contents

As a result of impairment indicators related to the weakness in the housing market we identified during the second quarter of 2008, the Company evaluated its trademarks for impairment and compared the estimated fair value of its trademarks to their carrying value and preliminarily determined that there was no impairment. During the third quarter of 2008, as part of finalizing its second quarter impairment tests, the Company made certain changes to its projections that affected the previous estimate of fair value and, when compared to the carrying value of indefinite lived intangibles, resulted in a $0.3 million impairment charge in the third quarter of 2008. We performed our annual assessment of our trademarks as of January 3, 2009. Given a further decline in housing starts and the overall tightening of the credit markets, our revised forecasts indicated additional impairment was present, resulting in an additional impairment charge of $17.8 million in the fourth quarter of 2008. After impairment charges totaling $18.1 million in 2008, intangible assets not subject to amortization totaled $44.4 million at July 4, 2009. We concluded that no events or changes in circumstances occurred during the second quarter of 2009 that would indicate that our trademarks are further impaired or that an impairment test was required.

Amortizable Intangible Asset

As a result of the impairment indicators described above, during the second quarter of 2008 and again as of January 3, 2009, we tested our amortizable intangible asset, which is our customer relationships intangible asset, for impairment by comparing the estimated future undiscounted net cash flows expected to be generated by the asset group containing this asset to its carrying value and determined that there was no impairment.

NOTE 8. LONG-TERM DEBT

On February 14, 2006, we entered into a second amended and restated $235 million senior secured credit facility and a $115 million second lien term loan due August 14, 2012, with a syndicate of banks. The senior secured credit facility is composed of a $30 million revolving credit facility and, initially, a $205 million first lien term loan. As of July 4, 2009, there was $25.2 million available under the revolving credit facility.

On April 30, 2008, we announced that we entered into an amendment to the credit agreement. The amendment, among other things, relaxed certain financial covenants through the first quarter of 2010, increased the applicable rate on loans and letters of credit, and set a LIBOR floor. The effectiveness of the amendment was conditioned, among other things, on the repayment of at least $30 million of loans under the credit agreement no later than August 14, 2008, of which no more than $15 million was permitted to come from cash on hand. In June 2008, the Company used cash generated from operations to prepay $10 million of outstanding borrowings under the credit agreement.

On August 1, 2008, the Company filed Amendment No. 1 to the Registration Statement on Form S-3 filed on March 28, 2008 relating to a previously announced offering of rights to purchase 7,082,687 shares of the Company’s common stock with an aggregate value of approximately $30 million. The registration statement relating to the rights offering was declared effective by the United States Securities and Exchange Commission on August 4, 2008, and the Company distributed to each holder of record of the Company’s common stock as of close of business on August 4, 2008, at no charge, one non-transferable subscription right for every four shares of common stock held by such holder under the basic subscription privilege. Each whole subscription right entitled its holder to purchase one share of PGT’s common stock at the subscription price of $4.20 per share. The rights offering expired on September 4, 2008.

The rights offering was fully subscribed resulting in the Company distributing all 7,082,687 shares of its common stock available. Net proceeds of $29.3 million from the rights offering were used to repay a portion of the outstanding indebtedness under our amended credit agreement.

- 10 -

Table of Contents

Using proceeds from the rights offering, the Company made an additional prepayment of $20 million on August 11, 2008, bringing total prepayments of debt at that time to $30 million as required under the amended credit agreement. Having made the total required prepayment and having satisfied all other conditions to bring the amendment into effect, including the payment of the fees and expenses of the administrative agent and a consent fee to participating lenders of 25 basis points of the then outstanding balance under the credit agreement of $100 million, the amendment became effective on August 11, 2008. Fees paid to the administrative agent and lenders totaled $0.6 million and have been deferred, and the unamortized balance of $0.4 million is included in other assets on the accompanying condensed consolidated balance sheet as of July 4, 2009. Such fees are being amortized on a straight-line basis, which approximates the effective interest method, over the remaining term of the credit agreement.

Under the amendment, the first lien term loan bears interest at a rate equal to an adjusted LIBOR rate plus a margin ranging from 3.5% per annum to 5% per annum or a base rate plus a margin ranging from 2.5% per annum to 4.0% per annum, at our option. The margin in either case is dependent on our leverage ratio. The loans under the revolving credit facility bear interest at a rate equal to an adjusted LIBOR rate plus a margin depending on our leverage ratio ranging from 3.0% per annum to 4.75% per annum or a base rate plus a margin ranging from 2.0% per annum to 3.75% per annum, at our option. The amendment established a floor of 3.25% for adjusted LIBOR.

A commitment fee equal to 0.50% per annum accrues on the average daily unused amount of the commitment of each lender under the revolving credit facility and such fee is payable quarterly in arrears. We are also required to pay certain other fees with respect to the senior secured credit facility including (i) letter of credit fees on the aggregate undrawn amount of outstanding letters of credit plus the aggregate principal amount of all letter of credit reimbursement obligations, (ii) a fronting fee to the letter of credit issuing bank and (iii) administrative fees.

The first lien term loan is secured by a perfected first priority pledge of all of the equity interests of our subsidiary and perfected first priority security interests in and mortgages on substantially all of our tangible and intangible assets subject to such exceptions as are agreed. The senior secured credit facility contains a number of covenants that, among other things, restrict our ability and the ability of our subsidiary to (i) dispose of assets; (ii) change our business; (iii) engage in mergers or consolidations; (iv) make certain acquisitions; (v) pay dividends; (vi) incur indebtedness or guarantee obligations and issue preferred and other disqualified stock; (vii) make investments and loans; (viii) incur liens; (ix) engage in certain transactions with affiliates; (x) enter into sale and leaseback transactions; (xi) issue stock or stock options under certain conditions; (xii) amend or prepay subordinated indebtedness and loans under the second lien secured credit facility; (xiii) modify or waive material documents; or (xiv) change our fiscal year. In addition, under the senior secured credit facility, we are required to comply with specified financial ratios and tests, including a minimum interest coverage ratio, a maximum leverage ratio, and maximum capital expenditures.

Contractual future maturities of long-term debt and capital leases as of July 4, 2009 are as follows (in thousands):

Remainder of 2009	$	50
2010		531
2011		965
2012		80,772
Total	$	82,318

During June 2009, we prepaid $8.0 million of long-term debt using cash generated from operations during the second quarter of 2009 and cash on hand. During 2008, we prepaid $40.0 million of long-term debt with cash generated from operations and the net proceeds of the rights offering, which totaled $29.3 million.

- 11 -

Table of Contents

On an annual basis, our Company is required to compute excess cash flow, as defined in our credit and security agreement with the bank. In periods where there is excess cash flow, our Company is required to make prepayments in an aggregate principal amount determined through reference to a grid based on the leverage ratio. No such prepayments were required for the year ended January 3, 2009. The term note and line of credit require that our Company also maintain compliance with certain financial covenants, one of which requires our Company to maintain a total leverage ratio, as defined in the credit agreement, as amended, of not greater than certain predetermined amounts. Our Company was in compliance with all financial covenants as of July 4, 2009.

NOTE 9. COMPREHENSIVE LOSS AND ACCUMULATED OTHER COMPREHENSIVE (LOSS) INCOME

The following table shows the components of comprehensive income (loss) for the three and six month periods ended July 4, 2009 and June 28, 2008:


	Three Months Ended					Six Months Ended
	July 4,		June 28,			July 4,			June 28,
	2009		2008			2009			2008
	(in thousands)					(in thousands)
Net income (loss)	$	342	$	(76,649	)	$	(6,358	)	$	(78,436	)

Other comprehensive income (loss), net of taxes:
Change related to interest rate swap, net of
tax expense of $28 for the six months
ended June 28, 2008		-		-			-			46
Change related to forward contracts for
aluminum, net of tax expense of $0 and tax
benefit of $79 for the three month periods ended
July 4, 2009 and June 28, 2008, respectively, and
net of tax expense of $0 and $311 for the six
month periods ended July 4, 2009 and June 28,
2008, respectively		1,478		(124	)		1,897			485

Total comprehensive income (loss)	$	1,820	$	(76,773	)	$	(4,461	)	$	(77,905	)

- 12 -

Table of Contents

The following table shows the components of accumulated other comprehensive income (loss) for the three and six month periods ended July 4, 2009 and June 28, 2008:


				Aluminum
				Forward			Valuation
(in thousands)				Contracts			Allowance			Total
Balance at April 4, 2009				$	(2,508	)	$	(1,039	)	$	(3,547	)
Changes in fair value					380			-			380
Reclassification to earnings					1,098			-			1,098
Tax (expense) benefit					(541	)		541			-
Balance at July 4, 2009				$	(1,571	)	$	(498	)	$	(2,069	)

				Aluminum
	Interest Rate			Forward			Valuation
(in thousands)	Swap			Contracts			Allowance			Total
Balance at March 29, 2008	$	-		$	233		$	-		$	233
Changes in fair value		-			67			-			67
Reclassification to earnings		-			(270	)		-			(270	)
Tax (expense) benefit		-			79			-			79
Balance at June 28, 2008	$	-		$	109		$	-		$	109

				Aluminum
				Forward			Valuation
(in thousands)				Contracts			Allowance			Total
Balance at January 3, 2009				$	(2,584	)	$	(1,382	)	$	(3,966	)
Changes in fair value					(597	)		-			(597	)
Reclassification to earnings					2,494			-			2,494
Tax (expense) benefit					(884	)		884			-
Balance at July 4, 2009				$	(1,571	)	$	(498	)	$	(2,069	)

				Aluminum
	Interest Rate			Forward			Valuation
(in thousands)	Swap			Contracts			Allowance			Total
Balance at December 29, 2007	$	(46	)	$	(376	)	$	-		$	(422	)
Changes in fair value		74			1,130			-			1,204
Reclassification to earnings		-			(334	)		-			(334	)
Tax (expense) benefit		(28	)		(311	)		-			(339	)
Balance at June 28, 2008	$	-		$	109		$	-		$	109

NOTE 10. COMMITMENTS AND CONTINGENCIES

Litigation

Our Company is a party to various legal proceedings in the ordinary course of business. Although the ultimate disposition of those proceedings cannot be predicted with certainty, management believes the outcome of any claim that is pending or threatened, either individually or in the aggregate, will not have a materially adverse effect on our operations, financial position or cash flows.

- 13 -

Table of Contents

NOTE 11. INCOME TAXES

The Company adopted the provisions of Financial Accounting Standards Board (FASB) Interpretation No. 48 (FIN 48), “Accounting for Uncertainty in Income Taxes, an interpretation of FASB Statement No. 109, Accounting for Income Taxes”, on January 1, 2007. We did not recognize any material liability for unrecognized tax benefits in conjunction with our FIN 48 implementation, and there were no changes to our unrecognized tax benefits during 2008 or the first six months of 2009. However, should we accrue for such liabilities if they arise in the future, we will recognize interest and penalties associated with uncertain tax positions as part of our income tax provision.

In 2008, we established a valuation allowance to reduce to zero our net deferred tax assets, excluding the $17.3 million deferred tax liability related to trademarks. Driven by the goodwill and other intangible impairment charges recorded in 2008 totalling $187.7 million, our cumulative losses over the last three fiscal years, as well as the significant downturn in our primary industry of home construction, we concluded that sufficient negative evidence existed that it was deemed more likely than not future taxable income will not be sufficient to realize the related income tax benefits. Of the $7.4 million valuation allowance at July 4, 2009, $0.5 million was allocated to accumulated other comprehensive loss in the accompanying consolidated balance sheet at that date to offset the tax benefit that is recorded in accumulated other comprehensive loss.

We had an effective tax rate of zero for the three and six month periods ended July 4, 2009. Changes in deferred tax assets and liabilities during the second quarter and first half of 2009 were offset by changes in the valuation allowance for deferred tax assets. Excluding the change in the valuation allowance, the effective tax rate in the second quarter and first half of 2009 would have been tax expense of 94.6% and a benefit of 35.4%, respectively. The effective tax rate in the second quarter of 2009, excluding the change in the valuation allowance, was the result of the effect of permanent differences that occurred during the quarter relative to income before income taxes of only $0.3 million.

We had an effective tax rate of a benefit of 13.8% for the three months and 14.5% for the six months ended June 28, 2008. Excluding deferred tax benefits totaling $13.5 million related to the $92 million estimated goodwill impairment charge recorded in the second quarter of 2008 and a $0.1 million valuation allowance recorded against the deferred tax assets for North Carolina state tax credits, we would have had an effective tax rate of 36.6% for the second quarter and 36.7% for the first half of 2008.

NOTE 12. FINANCIAL INSTRUMENTS AND DERIVATIVE FINANCIAL INSTRUMENTS

Financial Instruments

Our financial instruments, not including derivative financial instruments discussed below, include cash, accounts receivable, accounts payable and capital leases whose carrying amounts approximate their fair values due to their short-term nature. Our financial instruments also include long-term debt. Based on observed transactions, the fair value of our long-term debt was approximately $51 million at July 4, 2009 and $63 million at January 3, 2009.

Derivative Financial Instruments

We enter into aluminum forward contracts to hedge fluctuations in the purchase price of aluminum extrusion we use in production. At July 4, 2009, we had 46 outstanding forward contracts for the purchase of 9.8 million pounds of aluminum at an average price of $0.95 per pound with maturity dates of between one month and eighteen months through December 2010. These contracts are designated as cash flow hedges since they are highly effective in offsetting changes in cash flow attributable to forecasted purchases of aluminum. These aluminum hedges were in a liability position at July 4, 2009 and had a fair value of $2.0 million. We maintain a line of credit of $0.4 million with our commodities broker to cover the liability position of open contracts for the purchase of aluminum in the event that the price of aluminum falls. Should the price of aluminum fall to a level which causes our liability for open aluminum contracts to exceed $0.4 million, we must fund daily margin calls to cover the excess. We entered into a master netting arrangement (MNA) with our commodities broker that provides for, among other things, the immediate close-out netting of exchange-traded transactions in the event of our failure to make any required contract payments or upon the commencement of insolvency proceedings, voluntary or otherwise.

- 14 -

Table of Contents

As of July 4, 2009, we had $1.5 million of cash on deposit with our commodities broker related to funding of margin calls on open forward contracts for the purchase of aluminum in a liability position. We net cash collateral from payments of margin calls on deposit with our commodities broker against the liability position of open contracts for the purchase of aluminum on a first-in, first-out basis. For statement of cash flows presentation, we present net cash receipts from and payments to the margin account as investing activities.

The fair value of our aluminum hedges under SFAS 133, “Accounting for Derivative Instruments and Hedging Activities” are classified in the accompanying condensed consolidated balance sheets as follows (in thousands):


		July 4,			January 3,
		2009			2009
Derivatives in a liability position	Balance Sheet Location
Hedging instruments under SFAS 133:
Aluminum forward contracts	Accrued liabilities	$	(1,607	)	$	(2,471	)
Aluminum forward contracts	Other liabilities		(362	)		(1,765	)
Cash on deposit related to payments of margin calls	Accrued liabilities		1,530			2,471
Cash on deposit related to payments of margin calls	Other liabilities		-			1,627

Total hedging instruments under SFAS 133		$	(439	)	$	(138	)

Our aluminum hedges qualify as highly effective for reporting purposes. Effectiveness of aluminum forward contracts is determined by comparing the change in the fair value of the forward contract to the change in the expected cash to be paid for the hedged item. At July 4, 2009, these contracts were designated as effective. The effective portion of the gain or loss on our aluminum forward contracts is reported as a component of other comprehensive income and is reclassified into earnings in the same line item in the income statement as the hedged item in the same period or periods during which the transaction affects earnings. For the three and six month periods ended July 4, 2009 and June 28, 2008, there were no amounts reclassified to earnings due to a forecasted transaction being deemed improbable of occurring. The ending accumulated balance for the aluminum forward contracts included in accumulated other comprehensive loss is $2.3 million as of July 4, 2009, of which $2.0 million is expected to be reclassified to earnings in the next twelve months based on scheduled settlement dates of the related contracts. The following represents the gains (losses) on derivative financial instruments for the three and six month periods ended July 4, 2009 and June 28, 2009, and their classifications within the accompanying condensed consolidated financial statements (in thousands):

- 15 -

Table of Contents


Derivatives in SFAS 133 Cash Flow Hedging Relationships
	Amount of Gain or (Loss) Recognized in OCI on Derivatives (Effective Portion)					Location of Gain or (Loss) Reclassified from Accumulated OCI into Income (Effective Portion)	Amount of Gain or (Loss) Reclassified from Accumulated OCI into Income (Effective Portion)					Location of Gain or (Loss) Recognized in Income on Derivatives (Ineffective Portion)	Amount of Gain or (Loss) Recognized in Income on Derivatives (Ineffective Portion)
	Three Months Ended						Three Months Ended						Three Months Ended
	July 4,			June 28,			July 4,			June 28,			July 4,			June 28,
	2009			2008			2009			2008			2009			2008

Aluminum contracts	$	380		$	146	Cost of sales	$	(1,098	)	$	270	Other income or other expense	$	-		$	(51	)
Interest rate swap		-			-			-			-			-			-

	$	380		$	146		$	(1,098	)	$	270		$	-		$	(51	)

	Six Months Ended						Six Months Ended						Six Months Ended
	July 4,			June 28,			July 4,			June 28,			July 4,			June 28,
	2009			2008			2009			2008			2009			2008

Aluminum contracts	$	(597	)	$	819	Cost of sales	$	(2,494	)	$	334	Other income or other expense	$	(6	)	$	56
Interest rate swap		-			46			-			-			-			-

	$	(597	)	$	865		$	(2,494	)	$	334		$	(6	)	$	56

Aluminum forward contracts identical to those held by the Company trade on the London Metals Exchange (“LME”). The LME provides a forum for the trading of futures contracts for non-ferrous metals and plastics. The trading is highly liquid and, therefore, the metals industry has a high degree of confidence that the trade pricing properly reflects current supply and demand. The prices are used by the metals industry worldwide as the basis for contracts for the movement of physical material throughout the production cycle. Trade pricing is based on valuation model inputs that can generally be verified but which require some degree of judgment. Therefore, we categorize these aluminum forward contracts as being valued using Level 2 inputs as follows:


	Fair Value Measurements at Reporting Date
	of Asset (Liability) Using:
				Quoted		Significant			Significant
				Prices in		Other Observable			Unobservable
	July 4,			Active Markets		Inputs			Inputs
Description	2009			(Level 1)		(Level 2)			(Level 3)
	(in thousands)

Forward contracts for aluminum	$	(1,969	)	$	-	$	(1,969	)	$	-
Cash on deposit related to payments of margin calls		1,530
Forward contracts for aluminum, net liability	$	(439	)

- 16 -

Table of Contents

NOTE 13. RECENTLY ADOPTED AND ISSUED ACCOUNTING PRONOUNCEMENTS

In September 2006, the FASB issued Statement of Financial Accounting Standards (SFAS) No. 157, “Fair Value Measurements” (SFAS 157). SFAS 157 defines fair value, establishes a framework for measuring fair value, and expands disclosures about fair value measurements. We partially adopted SFAS 157 on January 1, 2008, as required for our financial assets and financial liabilities. However, the FASB deferred the effective date of SFAS 157 for one year as it relates to fair value measurement requirements for non-financial assets and non-financial liabilities that are not recognized or disclosed at fair value on a recurring basis. We adopted these remaining provisions of SFAS 157 on January 4, 2009. The adoption of SFAS 157 did not have a material impact on our consolidated financial statements.

SFAS 141 (revised 2007) (SFAS 141R), “Business Combinations” was issued in December 2007. SFAS 141R establishes principles and requirements for how the acquirer of a business recognizes and measures in its financial statements the identifiable assets acquired, the liabilities assumed, and any noncontrolling interest in the acquiree. SFAS 141R also provides guidance for recognizing and measuring the goodwill acquired in the business combination and determines what information to disclose to enable users of the financial statements to evaluate the nature and financial effects of the business combination. SFAS 141R was effective for us in our fiscal year beginning January 4, 2009. We will apply the provisions of SFAS 141R to future acquisitions, if any.

In March 2008, the FASB issued SFAS 161, “Disclosures about Derivative Instruments and Hedging Activities—an amendment of FASB Statement No. 133”. SFAS 161 requires entities that utilize derivative instruments to provide qualitative disclosures about their objectives and strategies for using such instruments, as well as any details of credit-risk-related contingent features contained within derivatives. SFAS 161 also requires entities to disclose additional information about the amounts and location of derivatives located within the financial statements, how the provisions of SFAS 133 have been applied, and the impact that hedges have on an entity’s financial position, financial performance, and cash flows. SFAS 161 was effective for fiscal years and interim periods beginning after November 15, 2008. We adopted SFAS 161 effective on January 4, 2009 and have provided the required information in Note 12.

In April 2008, the FASB issued Financial Staff Position (FSP) 142-3, “Determination of the Useful Life of Intangible Assets”, (FSP 142-3). FSP 142-3 amends the factors that should be considered in developing renewal or extension assumptions used to determine the useful life of a recognized intangible asset under SFAS 142, “Goodwill and Other Intangible Assets”. FSP 142-3 was effective for fiscal years beginning after December 15, 2008. We adopted SFAS FSP 142-3 effective on January 4, 2009 with no impact on our consolidated financial position and results of operations.

In May 2009, the FASB issued SFAS 165, “Subsequent Events”. SFAS 165 establishes general standards of accounting for and disclosure of events that occur after the balance sheet date but before financial statements are issued or are available to be issued. We adopted SFAS 165 during the second quarter of 2009 on a prospective basis. The adoption did not materially impact our consolidated financial statements. See note 1 for our evaluation of subsequent events.

In April 2009, the FASB issued three FSPs that are intended to provide additional application guidance and enhance disclosures about fair value measurements and impairments of securities. FSP FAS 157-4 clarifies the objective and method of fair value measurement even when there has been a significant decrease in market activity for the asset being measured. FSP FAS 115-2 and FAS 124-2 establish a new model for measuring other-than-temporary impairments for debt securities, including establishing criteria for when to recognize a write-down through earnings versus other comprehensive income. FSP FAS 107-1 and APB 28-1 expands the fair value disclosures required for all financial instruments within the scope of SFAS 107, “Disclosures about Fair Value of Financial Instruments”, to interim periods. The adoption of FSP FAS 157-4 and FSP FAS 115-2 and FAS 124-2 did not impact our consolidated financial statements. FSP FAS 107-1 and APB 28-1 resulted in increased interim disclosures related to our financial instruments.

- 17 -

Table of Contents

NOTE 14. COLLABORATIVE ARRANGEMENT

In view of the risks and costs associated with developing new products and our desire to expand our markets by providing quality unitized curtain wall solutions to the commercial building industry, we entered into a collaborative arrangement with another company with extensive experience in sales, marketing, engineering and project management of unitized curtain wall solutions and in which costs, revenues and risks are shared. We are not the principal participant in this arrangement. Our obligation under this arrangement is to provide manufacturing expertise, including providing the operating entity with labor for assembly and fabrication of the unitized curtain wall units. We earn revenues and incur costs of sales and expenses from this activity based on the number of hours of labor provided in the production of materials used in the arrangement. We also record a percentage of the joint operating activity’s profit or loss into revenue based on our percentage interest in the arrangement, which was insignificant in the second quarter and first half of 2009. As of July 4, 2009, each collaborator’s interest was 50 percent.

The following table illustrates the income statement classification and amounts attributable to transactions arising from the collaborative arrangements between participants for each period presented (in thousands):


	Three Months Ended					Six Months Ended
	July 4,			June 28,		July 4,			June 28,
	2009			2008		2009			2008
	(unaudited)					(unaudited)
Net sales	$	125		$	52	$	1,449		$	52
Cost of sales		(296	)		-		(1,093	)		-
Selling, general and administrative		(81	)		-		(215	)		-

In November 2007, the EITF issued EITF 07-1, “Accounting for Collaborative Arrangements”. This Issue is effective for financial statements issued for fiscal years beginning after December 15, 2008, and interim periods within those fiscal years, and must be applied retrospectively to all prior periods presented for all collaborative arrangements existing as of the effective date. This Issue requires that participants in a collaborative arrangement report costs incurred and revenues generated on a gross or net basis and in the appropriate line items in each company’s financial statements pursuant to the guidance in EITF Issue No. 99-19, “Reporting Revenue Gross as a Principal versus Net as an Agent.” This Issue also requires disclosure of the nature and purpose of the participant’s collaborative arrangements, the participant’s rights and obligations under these arrangements, the accounting policy for collaborative arrangements, the income statement classification and amounts attributable to transactions arising from collaboration arrangements between participants, and the disclosure related to individually significant collaborative arrangements. We adopted EITF 07-1 in the second quarter of 2008.

- 18 -

Table of Contents

ITEM 2. MANAGEMENT’S DISCUSSION AND ANALYSIS OF FINANCIAL CONDITION AND RESULTS OF OPERATIONS

The following discussion of our financial condition and results of operations should be read in conjunction with the Management’s Discussion and Analysis of Financial Condition and Results of Operations and the consolidated financial statements and notes thereto for the year ended January 3, 2009 included in our most recent annual report on Form 10-K.

Special Note Regarding Forward-Looking Statements

This document includes forward-looking statements regarding, among other things, our financial condition and business strategy. Forward-looking statements provide our current expectations and projections about future events. Forward-looking statements include statements about our expectations, beliefs, plans, objectives, intentions, assumptions, and other statements that are not historical facts. As a result, all statements other than statements of historical facts included in this discussion and analysis and located elsewhere in this document regarding the prospects of our industry and our prospects, plans, financial position, and business strategy may constitute forward-looking statements within the meaning of Section 21E of the Exchange Act. In addition, forward-looking statements generally can be identified by the use of forward-looking terminology such as “may,” “could,” “expect,” “intend,” “estimate,” “anticipate,” “plan,” “foresee,” “believe,” or “continue,” or the negatives of these terms or variations of them or similar terminology, but the absence of these words does not necessarily mean that a statement is not forward-looking.

Forward-looking statements are subject to known and unknown risks and uncertainties and are based on potentially inaccurate assumptions that could cause actual results to differ materially from those expected or implied by the forward-looking statements. Although we believe that the expectations reflected in these forward-looking statements are reasonable, we can give no assurance that these expectations will occur as predicted. All subsequent written and oral forward-looking statements attributable to us or persons acting on our behalf are expressly qualified in their entirety by the cautionary statements included in this document. These forward-looking statements speak only as of the date of this report. We undertake no obligation to publicly update or revise any forward-looking statement to reflect circumstances or events after the date of this report or to reflect the occurrence of unanticipated events, except as may be required by applicable securities laws.

Risks associated with our business, an investment in our securities, and with achieving the forward-looking statements contained in this report or in our news releases, Web sites, public filings, investor and analyst conferences or elsewhere, include, but are not limited to, the risk factors described in our most recent Annual Report on Form 10-K filed with the Securities and Exchange Commission. Any of the risk factors described therein could cause our actual results to differ materially from expectations and could have a material adverse effect on our business, financial condition or results of operations. We may not succeed in addressing these challenges and risks.

Current Operating Conditions and Outlook

In the second quarter of 2009, new housing permits in Florida decreased 44% compared to the second quarter of 2008 but were up 6% from the first quarter of 2009. The homebuilding industry began to show some positive signs in the second quarter of 2009 as several of the nation’s largest home builders reported increases in new home orders and decreases in cancellation rates. Also, construction of new homes in the U.S. rose in June to the highest level in seven months, and applications for building permits recently began increasing. . However, the availability of credit remained tight and there was a steady rate of foreclosures, leaving a glut of unoccupied homes on the market. The economy continued to shed jobs as the rate of unemployment reached nearly 10% nationally. Based in part on these factors, we believe home construction industry still faces a long recovery period.

Difficult economic conditions persisted in the United States during the second quarter of 2009, and the housing industry, most notably in the Company’s primary market of Florida, has been in a period of prolonged deterioration. These conditions may persist and remain depressed for the foreseeable future. Economic conditions have been negatively impacted by slowing growth and the mortgage crisis ultimately causing liquidity and credit concerns. Continuing adverse economic conditions in our markets could likely negatively impact our business, which could result in reduced demand for our products, increased price competition, increased risk in the collectability of cash from our customers potentially resulting in increased reserves for doubtful accounts and write-offs of accounts receivable, and higher operating costs. If economic conditions deteriorate further, we may experience adverse impacts on our business, operating results and financial condition.

- 19 -

Table of Contents

In response to the deterioration in the housing market, we have taken a number of steps to enhance profitability and conserve capital. As discussed in “Other Developments – Restructurings” below, we adjusted our operating cost structure to more closely align with current demand. In addition, we decreased our capital spending in 2008 and have further restricted capital spending in the first half of 2009. However, we also view this market downturn as an opportunity to gain market share from our competitors. For instance, we increased marketing and sales efforts in areas outside of our dominant markets, including northern Florida, the Gulf Coast and the Carolinas and other southeastern states resulting in incremental sales outside of Florida compared to last year. Also, we introduced new products in 2009 and expanded product lines to broaden our product offering. As a result of these actions, we continue to outperform the underlying market. However, gross margins have declined to 31.2% in the second quarter of 2009 from 35.8% in the second quarter of 2008, and to 27.7% in the first half of 2009 from 32.7% in the first half of 2008 due, mainly, to the impact of the loss of operating leverage against fixed costs from a decline in sales and restructuring costs.

While the homebuilding industry is in a down cycle, we still believe the long-term outlook for the industry is positive due to growth in the underlying demographics. At this point, it appears as though the housing market has not yet hit bottom. Despite these unfavorable market conditions, we still believe that, in the long-term, we can grow organically by gaining market share and outperforming our underlying markets. However, we believe difficult market conditions affecting our business will continue, and the recent downturn in the economy as a result of the mortgage crisis may further negatively affect our operating results and year-over-year comparisons.

Other Developments

Restructurings

On January 13, 2009 and March 11, 2009, we announced further restructurings of the Company as a result of continued analysis of our target markets, internal structure, projected run-rate, and efficiency. The restructurings resulted in a decrease in our workforce of approximately 250 employees and included employees at both of our Venice, Florida and Salisbury, North Carolina locations. As a result of the restructurings, we recorded restructuring charges totaling $3.0 million in the first quarter of 2009, of which $1.4 million is classified within cost of goods sold and $1.6 million is classified within selling, general and administrative expenses in the accompanying condensed consolidated statement of operations for the six months ended July 4, 2009. The charges relate primarily to employee separation costs.

Selected Financial Data

The following table presents financial data derived from our unaudited statements of operations as a percentage of total revenues for the periods indicated.

	Three Months Ended					Six Months Ended
	July 4,		June 28,			July 4,			June 28,
	2009		2008			2009			2008

Net sales		100.0%		100.0%			100.0%			100.0%
Cost of sales		68.8%		64.2%			72.3%			67.3%
Gross margin		31.2%		35.8%			27.7%			32.7%
Goodwill impairment charge		-		153.1%			-			80.0%
Selling, general and administrative expenses		26.8%		26.9%			31.2%			28.2%
Income (loss) from operations		4.4%		(144.2%	)		(3.5%	)		(75.5%	)
Interest expense, net		3.7%		3.6%			3.8%			4.3%
Other expense (income), net		-		0.1%			-			-
Income (loss) before income taxes		0.7%		(147.9%	)		(7.3%	)		(79.8%	)
Income tax benefit		-		(20.4%	)		-			(11.6%	)
Net income (loss)		0.7%		(127.5%	)		(7.3%	)		(68.2%	)

- 20 -

Table of Contents

RESULTS OF OPERATIONS FOR THE THREE MONTHS ENDED JULY 4, 2009 AND JUNE 28, 2008

Net sales

Net sales decreased nearly $13.2 million, or 22.0%, in the second quarter of 2009, compared to the 2008 second quarter. Net sales for the second quarter of 2009 were $46.9 million, compared with net sales of $60.1 million for the second quarter of 2008. The following table shows net sales classified by major product category (sales in millions):


	Three Months Ended
	July 4, 2009				June 28, 2008
	Sales		% of sales		Sales		% of sales		% change
Product category:
WinGuard Windows and Doors	$	32.2		68.7%	$	41.8		69.6%		(23.0%)
Other Window and Door Products		14.7		31.3%		18.3		30.4%		(19.9%)

Total net sales	$	46.9		100.0%	$	60.1		100.0%		(22.0%)

Net sales of WinGuard branded products were $32.2 million for the second quarter of 2009, a decrease of $9.6 million, or 23.0%, from $41.8 million in net sales for the 2008 second quarter. The decrease in sales of our WinGuard branded products was driven mainly by the decline in new home and repair and remodeling construction but also to some extent by the lack of storm activity during the two most recent hurricane seasons in the coastal markets of Florida served by the Company.

Net sales of Other Window and Door Products were $14.7 million for the second quarter of 2009, a decrease of $3.6 million, or 19.9%, from $18.3 million in net sales for the 2008 second quarter. The decrease was mainly due to the decline in the housing industry, partially offset by increases due to new product introductions, the sales related to unitized curtain wall, and increased sales in markets outside of the state of Florida.

Gross margin

Gross margin was $14.6 million, or 31.2% of sales, for the second quarter of 2009, a decrease of $6.9 million, or 32.0%, from $21.5 million, or 35.8% of sales, for the second quarter of 2008. This decrease was largely due to lower sales volumes of all of our products and the resulting loss of operating leverage against fixed costs, a change in mix and slight decrease in pricing, partially offset by spending reductions as a result of our cost savings initiatives.

Goodwill Impairment Charge

During the second quarter of 2008, the Company concluded that the weakness in the housing sector was likely to persist longer than previously anticipated by the Company based on its review of, among other things, sequential quarter housing starts in the second quarter of 2008 compared to the first quarter of 2008, the then recent turmoil surrounding the nation’s largest mortgage lenders and the resulting negative impact on the availability of mortgage financing and housing start forecasts published by national home builder associations pushing recovery in the new home construction market further out. The Company then concluded that this weakness in the housing market resulted in the prolonged decline in its market capitalization as compared to its then book value.

As a result of those impairment indicators, the Company updated the first step of its goodwill impairment test and determined that its carrying value exceeded its fair value, indicating that goodwill was impaired. Having determined that goodwill was impaired, we began performing the second step of the goodwill impairment test which involved calculating the implied fair value of our goodwill by allocating the fair value of the Company to all of our assets and liabilities other than goodwill (including both recognized and unrecognized intangible assets) and comparing it to the then carrying amount of goodwill. As of the date of the filing of the Company’s Quarterly Report on Form 10-Q for the quarter ended June 28, 2008, the Company estimated that the implied fair value of our goodwill was less than its carrying value by approximately $92.0 million, which the Company recognized as a goodwill impairment charge in the accompanying condensed consolidated results of operations for the second quarter ended June 28, 2008. The $92.0 million goodwill impairment charge was an estimate based on the results of the preliminary allocation of fair value in the second step. We completed our impairment test in the third quarter of 2008, which resulted in an additional non-cash goodwill impairment charge of $1.3 million.

- 21 -

Table of Contents

Selling, general and administrative expenses

Selling, general and administrative expenses were $12.5 million for the second quarter of 2009, a decrease of $3.6 million, from $16.2 million for the 2008 second quarter. This decrease was mainly due to a $2.6 million decrease in personnel related costs as the result of the cost saving actions, a $0.7 million decrease in fuel costs, a $0.4 million decrease in marketing and advertising costs and approximately $0.3 million of overall lower spending in other categories. These cost savings were partially offset by a $0.4 million increase in bad debt expense. As a percentage of sales, selling, general and administrative expenses were 26.8% the second quarter of 2009 compared to 26.9% for the second quarter of 2008.

Interest expense, net

Interest expense, net was $1.7 million in the second quarter of 2009, a decrease of $0.5 million, from $2.2 million for the second quarter of 2008. The decrease was due to a lower level of debt during the second quarter of 2009 compared to the second quarter of 2008 as the result of the prepayment of $40 million debt over the second and third quarters of 2008, partially offset by a higher interest rate on our debt which was a weighted average of 6.5% during the second quarter of 2009, compared to a weighted average of 6.1% during the second quarter of 2008.

Other expense (income), net

There was other expense of less than $0.1 million for the second quarter of 2008. The amounts in each quarter relate to the ineffective portions of aluminum hedges designated as effective over-hedges.

Income tax benefit

We had an effective tax rate of zero for the second quarter of 2009, compared to an income tax rate of a benefit of 13.8% for the second quarter of 2008. In the fourth quarter of 2008, we provided a valuation allowance on all our deferred tax assets because their realization in this difficult economy cannot be assured. Changes in deferred tax assets and liabilities during the second quarter of 2009 were offset by changes in the valuation allowance for deferred tax assets. Excluding the change in the valuation allowance, the effective tax rate in the second quarter of 2009 would have been an expense of 94.6%. The effective tax rate in the second quarter of 2009 excluding the change in the valuation allowance, was the result of the effect of permanent differences that occurred during the quarter relative to income before income taxes of only $0.3 million.

We had an effective tax rate of a benefit of 13.8% for the second quarter of 2008. Excluding deferred tax benefits totaling $13.5 million related to the $92 million estimated goodwill impairment charge recorded in the second quarter of 2008 and a $0.1 million valuation allowance recorded against the deferred tax assets for North Carolina state tax credits, we would have had an effective tax rate of 36.6% for the second quarter of 2008.

RESULTS OF OPERATIONS FOR FIRST HALF ENDED JULY 4, 2009 AND JUNE 28, 2008

Net sales

Net sales decreased $26.5 million, or 23.1%, in the first half of 2009, compared to the first half of 2008. Net sales for the first half of 2009 were $88.4 million, compared with net sales of $114.9 million for the first half of 2008. The following table shows net sales classified by major product category (sales in millions):

	First Half Ended
	July 4, 2009				June 28, 2008
	Sales		% of sales		Sales		% of sales		% change
Product category:
WinGuard Windows and Doors	$	60.0		67.9%	$	80.5		70.0%		(25.5%)
Other Window and Door Products		28.4		32.1%		34.4		30.0%		(17.6%)

Total net sales	$	88.4		100.0%	$	114.9		100.0%		(23.1%)

- 22 -

Table of Contents

Net sales of WinGuard branded products were $60.0 million for the first half of 2009, a decrease of $20.5 million, or 25.5%, from $80.5 million in net sales for the first half of 2008. The decrease in sales of our WinGuard branded products was driven mainly by the decline in new home and repair and remodeling construction but also to some extent by the lack of storm activity during the two most recent hurricane seasons in the coastal markets of Florida served by the Company.

Net sales of Other Window and Door Products were $28.4 million for the first half of 2009, a decrease of $6.0 million, or 17.6%, from $34.4 million in net sales for the first half of 2008. The decrease was mainly due to the decline in the housing industry, partially offset by increases due to new product introductions, the sales related to unitized curtain wall, and increased sales in markets outside of the state of Florida.

Gross margin

Gross margin was $24.5 million, or 27.7% of sales, for the first half of 2009, a decrease of $13.0 million, or 34.7%, from $37.6 million, or 32.7% of sales, for the first half of 2008. This decrease was largely due to lower sales volumes of all of our products and the resulting loss of operating leverage against fixed costs, a change in mix and slight decrease in pricing, partially offset by spending reductions as a result of our cost savings initiatives. There were restructuring charges in cost of goods sold in each period of $1.4 million in the first half of 2009 and $1.1 million in the first half of 2008. Adjusting for these charges, gross margin was $25.9 million, or 29.3% of sales, for the first half of 2009, compared to $38.6 million, or 33.6% of sales, for the first half of 2008, mainly due to the loss of leverage from the decrease in sales.

Goodwill Impairment Charge

Selling, general and administrative expenses

Selling, general and administrative expenses were $27.6 million for the first half of 2009, a decrease of $4.9 million, from $32.4 million for the first half of 2008. There were restructuring charges in selling, general and administrative expenses in each period of $1.6 million in the first half of 2009 and $0.7 million in the first half of 2008. Adjusting for these charges, selling, general and administrative expenses were $25.9 million for the first half of 2009, compared to $31.8 million for the first half of 2008, a decrease of $5.8 million. This decrease was mainly due to a $4.4 million decrease in personnel related costs as the result of the cost saving actions, a $1.0 million decrease in fuel costs, a $0.8 million decrease in marketing and advertising costs and approximately $0.4 million of overall lower spending in other categories. These cost savings were partially offset by a $0.8 million increase in bad debt expense. As a percentage of sales, adjusted selling, general and administrative expenses increased during the first half of 2009 to 29.3% compared to 27.6% for the first half of 2008, mainly due to the loss of leverage from the decrease in sales.

- 23 -

Table of Contents

Interest expense, net

Interest expense, net was $3.3 million in the first half of 2009, a decrease of $1.6 million, from $4.9 million for the first half of 2008. The decrease was due to a lower level of debt during the first half of 2009 compared to the first half of 2008 as the result of the prepayment of $40 million debt over the second and third quarters of 2008, and a lower interest rate on our debt which was a weighted average of 6.4% during the first half of 2009, compared to a weighted average of 7.1% during the first half of 2008.

Other expense (income), net

There was other expense of less than $0.1 million for the first half of 2009, compared to other income of less than $0.1 million for the first half of 2008. The amounts in each quarter relate to ineffective portions of aluminum hedges.

Income tax benefit

We had an effective tax rate of zero for the first half of 2009, compared to an income tax benefit rate of 14.5% for the first half of 2008. In the fourth quarter of 2008, we provided a valuation allowance on all our deferred tax assets because their realization in this difficult economy cannot be assured. Deferred tax assets created as a result of generating additional net operating loss carry-forwards in the first quarter of 2009 were equally offset by an increase in the valuation allowance. Excluding the change in the valuation allowance, the effective tax rate in the first half of 2009 would have been a tax benefit of 35.4%.

We had an effective tax rate of a benefit of 14.5% for the first half of 2008. Excluding deferred tax benefits totaling $13.5 million related to the $92 million estimated goodwill impairment charge recorded in the second quarter of 2008 and a $0.1 million valuation allowance recorded against the deferred tax assets for North Carolina state tax credits, we would have had an effective tax rate of 36.7% for the first half of 2008.

Liquidity and Capital Resources

Our principal source of liquidity is cash flow generated by operations, supplemented by borrowings under our credit facilities. This cash generating capability provides us with financial flexibility in meeting operating and investing needs. Our primary capital requirements are to fund working capital needs, meet required debt payments, including debt service payments on our credit facilities, and fund capital expenditures.

Consolidated Cash Flows

Operating activities. Cash provided by operating activities was $2.2 million in the first half of 2009 compared to $9.0 million in the half of 2008. This decrease was mainly due to lower operating profitability in the first half of 2009 than 2008. Direct cash flows from operations for the first half of 2009 and 2008 are as follows:


	Direct Cash Flows
	Six Months Ended
	July 4,			June 28,
(in millions)	2009			2008
Collections from customers	$	88.0		$	114.3
Other collections of cash		1.6			2.2
Disbursements to vendors		(51.1	)		(63.2	)
Personnel related disbursements		(34.2	)		(41.7	)
Debt service costs		(3.1	)		(4.9	)
Other cash activity, net		1.0			2.3

Cash provided by operations	$	2.2		$	9.0

- 24 -

Table of Contents

Other collections of cash in both the first half of 2009 and 2008 primarily represent scrap aluminum sales. The first half of 2009 also includes $0.7 million of proceeds from an insurance recovery. Other cash activity, net, in both periods is primarily composed of federal tax refunds.

Days sales outstanding (DSO), which we calculate as accounts receivable divided by average daily sales, was 41 days at July 4, 2009, and 39 days at January 3, 2009, compared to 38 days at June 28, 2008 and 37 days at December 29, 2007.

Investing activities. Cash provided by investing activities was $0.8 million for the first half of 2009, compared to cash used of $1.9 million for the first half of 2008. The increase of $2.7 million in cash from investing activities was mainly due to $2.2 million of net cash received from our margin account with our commodities broker related to returns of previously funded margin calls and settlements of forward contracts for aluminum, which we classify as investing activities, and a $0.5 million decrease in capital expenditures due to a lower level of capital spending in the first half of 2009 than in 2008.

Financing activities. Cash used in financing activities was $8.1 million in the first half of 2009, compared to cash used of $9.3 million in the first half of 2008. In June 2009, we prepaid $8.0 million of our long-term debt and in June 2008, we prepaid $10.0 million of our long-term debt, with cash generated from operations. Cash used in financing activities in the first half of 2008 includes cash proceeds from stock option exercises of $0.2 million and related excess tax benefits of $0.5 million. There were no options exercised in the first half of 2009.

Capital Resources. On February 14, 2006, we entered into a second amended and restated $235 million senior secured credit facility and a $115 million second lien term loan due August 14, 2012, with a syndicate of banks. The senior secured credit facility is composed of a $30 million revolving credit facility and, initially, a $205 million first lien term loan. As of July 4, 2009, there was $25.2 million available under the revolving credit facility.

- 25 -

Table of Contents

During June 2009, we prepaid an additional $8.0 million of long-term debt using cash generated from operations during the second quarter of 2009 and cash on hand.

The term note and line of credit require that we maintain compliance with certain financial covenants, one of which requires us to maintain a total leverage ratio, as defined in the credit agreement, as amended, of not greater than certain predetermined amounts. We were in compliance with all financial covenants as of July 4, 2009 and we will evaluate, if needed, what action or actions may be available or necessary to maintain compliance with our financial covenants, including cost saving actions and the prepayment of debt.

Based on our ability to generate cash flows from operations and our borrowing capacity under the revolver under the senior secured credit facility, we believe we will have sufficient capital to meet our short-term and long-term needs, including our capital expenditures and our debt obligations in 2009.

Capital Expenditures. Capital expenditures vary depending on prevailing business factors, including current and anticipated market conditions. For the first half of 2009, capital expenditures were $1.4 million, compared to $2.0 million for the first half of 2008. During 2008 and continuing into 2009, we reduced certain discretionary capital spending to conserve cash. We anticipate that cash flows from operations and liquidity from the revolving credit facility, if needed, will be sufficient to execute our business plans.

Hedging. We enter into aluminum forward contracts to hedge the fluctuations in the purchase price of aluminum extrusion we use in production. The Company enters into these contracts by trading on the London Metals Exchange (“LME”). The Company trades on the LME using an international commodities broker that offers global access to all major markets. The Company maintains a $0.4 million line of credit with its commodities broker to cover the liability position of open contracts for the purchase of aluminum in the event that the price of aluminum falls. Should the price of aluminum fall to a level which causes the Company’s liability for open aluminum contracts to exceed $0.4 million, the Company is required to fund daily margin calls to cover the excess. As of Saturday, July 4, 2009, the amount on deposit with our commodities broker of $1.5 million was less than the liability position of our aluminum forward contracts by $0.5 million due to movements in the price of aluminum on Friday, July 3, 2009. On Monday, July 6, 2009, we funded the $0.1 million difference between the net liability position of our aluminum contracts and our $0.4 million line of credit. As such, the full $0.4 million line of credit was used as of July 4, 2009.

- 26 -

Table of Contents

Contractual Obligations

There have been no significant changes to our “Disclosures of Contractual Obligations and Commercial Commitments” table in Part II, Item 7, “Management’s Discussion and Analysis of Financial Condition and Results of Operations” of our Annual Report on Form 10-K for the year ended January 3, 2009 as filed with the Securities and Exchange Commission on March 19, 2009.

Critical Accounting Policies and Estimates

Our consolidated financial statements are prepared in accordance with U.S. generally accepted accounting principles. Critical accounting policies are those that are both important to the accurate portrayal of a Company’s financial condition and results and require subjective or complex judgments, often as a result of the need to make estimates about the effect of matters that are inherently uncertain. We make estimates and assumptions that affect the amounts reported in our financial statements and accompanying notes. Certain estimates are particularly sensitive due to their significance to the financial statements and the possibility that future events may be significantly different from our expectations.

We identified our critical accounting policies in our Annual Report on Form 10-K for the year ended January 3, 2009 as filed with the Securities and Exchange Commission on March 19, 2009. There have been no changes to our critical accounting policies during the first half of 2009.

Related Party Transactions

In the ordinary course of business, we sell windows to Builders FirstSource, Inc., a company controlled by affiliates of JLL Partners, Inc. One of our directors, Floyd F. Sherman, is the president, chief executive officer, and a director of Builders FirstSource, Inc. In addition, Ramsey A. Frank, Brett N. Milgrim, and Paul S. Levy are directors of Builders FirstSource, Inc. Total net sales to Builders FirstSource, Inc. were $0.8 million and $1.5 million for the second quarter and first half of 2009 and $0.7 million and $1.4 million for the second quarter and first half of 2008. As of July 4, 2009 and January 3, 2009 there was $0.5 million and $0.2 million due from Builders FirstSource, Inc. included in accounts receivable in the accompanying consolidated balance sheets.

- 27 -

Table of Contents

ITEM 3. QUANTITATIVE AND QUALITATIVE DISCLOSURES ABOUT MARKET RISK

We experience changes in interest expense when market interest rates change. Changes in our debt could also increase these risks. Based on debt outstanding at July 4, 2009, a one percentage-point increase (decrease) in interest rates would result in approximately $0.8 million of additional (reduced) interest costs annually. As of July 4, 2009, we had no interest rate swaps or caps in place which means our debt is all adjustable-rate debt.

We utilize derivative financial instruments to hedge price movements in aluminum materials used in our manufacturing process. We entered into aluminum hedging instruments that settle at various times through the end of 2010 and cover approximately 70% of our anticipated needs during the remainder of 2009 at an average price of $0.99 per pound and 45% during 2010 at an average price of $0.94 per pound.

For forward contracts for the purchase of aluminum at July 4, 2009, a 10% decrease in the price of aluminum would decrease the fair value of our forward contacts of aluminum by $0.6 million.

ITEM 4. CONTROLS AND PROCEDURES

Disclosure Controls and Procedures. Disclosure controls and procedures are controls and other procedures that are designed to ensure that information required to be disclosed in the Company’s reports filed or submitted under the Exchange Act is recorded, processed, summarized and reported within the time periods specified in the Securities and Exchange Commission’s rules and forms.

A control system, however, no matter how well conceived and operated, can at best provide reasonable, not absolute, assurance that the objectives of the control system are met. Additionally, a control system reflects the fact that there are resource constraints, and the benefits of controls must be considered relative to costs. Because of the inherent limitations in all control systems, no evaluation of controls can provide absolute assurance that all control issues and instances of error or fraud, if any, within our Company have been detected, and due to these inherent limitations, misstatements due to error or fraud may occur and not be detected.

Our chief executive officer and chief financial officer, with the assistance of management, evaluated the design, operation and effectiveness of our disclosure controls and procedures (as defined in Rules 13a-15(e) and 15d-15(e) under the Exchange Act) as of the end of the period covered by this report (the “Evaluation Date”). Based on that evaluation, our chief executive officer and chief financial officer concluded that, as of the Evaluation Date, our disclosure controls and procedures were effective for the purposes of ensuring that information required to be disclosed in our reports filed under the Exchange Act is recorded, processed, summarized and reported within the time periods specified in the Securities and Exchange Commission’s rules and forms, and that such information is accumulated and communicated to management, including our chief executive officer and chief financial officer, as appropriate to allow timely decisions regarding required disclosure.

Changes in Internal Control over Financial Reporting. During the period covered by this report, there have been no changes in our internal control over financial reporting identified in connection with the evaluation described above that have materially affected, or are reasonably likely to materially affect, our internal control over financial reporting.

- 28 -

Table of Contents

PART II — OTHER INFORMATION

ITEM 1. LEGAL PROCEEDINGS

We are involved in various claims and lawsuits incidental to the conduct of our business in the ordinary course. We carry insurance coverage in such amounts in excess of our self-insured retention as we believe to be reasonable under the circumstances and that may or may not cover any or all of our liabilities in respect to claims and lawsuits. We do not believe that the ultimate resolution of these matters will have a material adverse impact on our financial position or results of operations.

Although our business and facilities are subject to federal, state and local environmental regulation, environmental regulation does not have a material impact on our operations. We believe that our facilities are in material compliance with such laws and regulations. As owners and lessees of real property, we can be held liable for the investigation or remediation of contamination on such properties, in some circumstances without regard to whether we knew of or were responsible for such contamination. Our current expenditures with respect to environmental investigation and remediation at our facilities are minimal, although no assurance can be provided that more significant remediation may not be required in the future as a result of spills or releases of petroleum products or hazardous substances or the discovery of previously unknown environmental conditions.

ITEM 1A. RISK FACTORS

In addition to the other information set forth in this report, you should carefully consider the factors discussed in Part 1, “Item 1A. Risk Factors” in our Annual Report on Form 10-K for the year ended January 3, 2009, which could materially affect our business, financial condition or future results. The risks described in our Annual Report on Form 10-K are not the only risks facing our Company. Additional risks and uncertainties not currently known to us or that we currently deem to be immaterial also may materially adversely affect our business, financial condition and/or operating results.

ITEM 2. UNREGISTERED SALES OF EQUITY SECURITIES AND USE OF PROCEEDS

Unregistered Sales of Equity Securities

None.

Use of Proceeds

Not applicable.

ITEM 3. DEFAULTS UPON SENIOR SECURITIES

None.

- 29 -

Table of Contents

ITEM 4. SUBMISSION OF MATTERS TO A VOTE OF SECURITY HOLDERS

At the Company's Annual Meeting of Stockholders held on May 12, 2009, the stockholders (1) elected 3 Class III directors, previously nominated by our Board of Directors, to serve until our 2012 annual meeting of stockholders and until their respective successors shall have been duly elected and qualified, and (2) ratified the appointment of Ernst & Young LLP as the Company’s independent registered public accounting firm for the 2009 fiscal year. Voting results were as follows:

(1) - Election of directors:	Votes For		Votes Withheld		Broker Non-Votes
Paul S. Levy		29,570,311		3,160,663		-
Rodney Hershberger		29,511,243		3,219,731		-
Floyd F. Sherman		32,663,713		67,261		-


(2) - Ratification of the appointment of Ernst & Young LLP:	Votes For		Votes Against		Abstaining
		32,616,513		16,964		97,497

ITEM 5. OTHER INFORMATION

None.

ITEM 6. EXHIBITS

The following items are attached or incorporated herein by reference:

31.1*	Certification of chief executive officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
31.2*	Certification of chief financial officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
32.1**	Certification of chief executive officer and chief financial officer pursuant to 18 U.S.C. Section 1350, as adopted pursuant to Section 906 of the Sarbanes-Oxley Act of 2002.

____________

* Filed herewith.

** Furnished herewith.

- 30 -

Table of Contents

SIGNATURES

Pursuant to the requirements of the Securities Exchange Act of 1934, the Registrant has duly caused this report to be signed on its behalf by the undersigned thereunto duly authorized.

	PGT, INC.
	(Registrant)

Date: August 12, 2009	/s/ Rodney Hershberger
	Rodney Hershberger
	President and Chief Executive Officer

Date: August 12, 2009	/s/ Jeffrey T. Jackson
	Jeffrey T. Jackson
	Executive Vice President and Chief Financial Officer

- 31 -

Table of Contents

EXHIBIT INDEX

31.1*	Certification of chief executive officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
31.2*	Certification of chief financial officer pursuant to Section 302 of the Sarbanes-Oxley Act of 2002.
32.1**	Certification of chief executive officer and chief financial officer pursuant to 18 U.S.C. Section 1350, as adopted pursuant to Section 906 of the Sarbanes-Oxley Act of 2002.

____________

* Filed herewith.

** Furnished herewith.

- 32 -

Table of Contents